Xerox DOCUTECH 65 Manual do Utilizador

Xerox Document Services PlatformDocuTech 65/DocuPrint 65Operator Guide701P36056DocuSP version 2.0.xJanuary 2001

Introduction Operator Guide-vi DocuTech 65/DocuPrint 65

DocuTech 65/DocuPrint 65 viiSafety notesPlease read the following instructions carefully before planning your install and/or operating the DocuTech 65

Safety notes Operator Guideviii DocuTech 65/DocuPrint 65WARNINGWarnings indicate possible serious personal injury if you do not strictly follow the pr

Operator Guide Safety notesDocuTech 65/DocuPrint 65 ixWARNINGThis is a Class A product. In a domestic environment this product may cause radio interfe

Safety notes Operator Guidex DocuTech 65/DocuPrint 65Electricity at Work Regulation - UKThe Electricity at Work Regulation applies only to England and

Operator Guide Safety notesDocuTech 65/DocuPrint 65 xiCheck your understandingPlease review the questions and answers that follow to ensure that you u

Safety notes Operator Guidexii DocuTech 65/DocuPrint 65Question Does the Xerox equipment in my premises comply with the Electricity at Work Regulation

Operator Guide Safety notesDocuTech 65/DocuPrint 65 xiiiElectrical safetyAttention to the following requirements ensures the safe operation of your eq

Safety notes Operator Guidexiv DocuTech 65/DocuPrint 65ControllerUSA/Canada The controller requires a dedicated 115V AC 20 Amp grounded receptacle.Eur

Operator Guide Safety notesDocuTech 65/DocuPrint 65 xvPrinter power on/off indicatorA power-on/power-off indicator shows the state of the power for th

Xerox CorporationGlobal Knowledge and Document Services800 Phillips RoadBuilding 845-17SWebster, New York 14580USA© 2001 by Xerox Corporation. All rig

Safety notes Operator Guidexvi DocuTech 65/DocuPrint 65Printer or controller - emergency power offIf any of the following conditions occur, turn off t

Operator Guide Safety notesDocuTech 65/DocuPrint 65 xviiPrinter - laser safetyCAUTIONThe use of controls, adjustments or performance of procedures oth

Safety notes Operator Guide-xviii DocuTech 65/DocuPrint 65Printer - operational safetySafety QualityStandardsThe equipment is manufactured under a BS5

Operator Guide Safety notesDocuTech 65/DocuPrint 65 -xixYour Xerox DocuTech 65/DocuPrint 65 printer is certified, manufactured, and tested in complian

Safety notes Operator Guide-xx DocuTech 65/DocuPrint 65

DocuTech 65/DocuPrint 65 1-11. Product overviewThis chapter will introduce the controller and overview the capabilities of the printer.Hardware compon

Product overview Operator Guide1-2 DocuTech 65/DocuPrint 65Controller componentsThe main controller components are shown in Figure 1-1.Figure 1-1. Con

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-3Printer componentsThe main components of the printer are shown in Figure 1-2.Figure 1-2. Pr

Product overview Operator Guide1-4 DocuTech 65/DocuPrint 65Paper trays (trays 1-4)Paper Trays 1-4 are shown below in Figure 1-3.Figure 1-3. Trays 1-4T

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-5Bypass tray (tray 5)The Bypass Tray (Tray 5) is an additional paper tray designed for quick

DocuTech 65/DocuPrint 65 1Table of contentsIntroduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iAb

Product overview Operator Guide1-6 DocuTech 65/DocuPrint 65High Capacity feeder (tray 6)The High Capacity Feeder (Tray 6) is located under the Bypass

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-7Tray guides and loading paperDo not open a tray that is in use, a paper jam may result. Ins

Product overview Operator Guide1-8 DocuTech 65/DocuPrint 65NOTE: For information about how to load specific types of paper or other stock, refer to

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-9Changing the Tray 6 settingsYou can set Tray 6 to hold either A4 or 8.5 x 11 inch paper.An

Product overview Operator Guide1-10 DocuTech 65/DocuPrint 65Rear Guide Starting with the Rear Guide, you will adjust the guide to the 8.5 x 11 inch po

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-11FinisherThe Finisher consists of the Top Tray and the Stacker Tray, as shown below in Figu

Product overview Operator Guide1-12 DocuTech 65/DocuPrint 65StaplingRemoving any of the output while the printer is running may produce finished sets

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-13Staple placementFor information about the limitations of portrait and landscape staple pla

Product overview Operator Guide1-14 DocuTech 65/DocuPrint 65Peripheral hardware componentsYou may have peripheral components such as an External SCSI

Operator Guide Product overviewDocuTech 65/DocuPrint 65 1-15Controller softwareThe controller runs the DocuSP Print Services software. This software g

Table of contents Operator Guide2 DocuTech 65/DocuPrint 65Finisher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Product overview Operator Guide1-16 DocuTech 65/DocuPrint 65

DocuTech 65/DocuPrint 65 2-12. MaintenanceYour Xerox DocuTech 65/DocuPrint 65 system is designed to maximize printer performance. This includes using

Maintenance Operator Guide2-2 DocuTech 65/DocuPrint 65Controller power-on procedureThe controller power-on button and the Light Emitting Diode (LED) a

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-3Printer power-on procedureWhen the printer is on, the power-on/power-off indicator glows green.

Maintenance Operator Guide2-4 DocuTech 65/DocuPrint 65Power-off proceduresYou can power off only the printer and allow the controller to keep on proce

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-5Figure 2-3. Printer power-offPrinter Power-Off Using The Red ButtonA red button, located inside

Maintenance Operator Guide2-6 DocuTech 65/DocuPrint 65Figure 2-4. Printer power-off, red buttonAfter the Red Button is used, the printer will take lon

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-7Controller power-offThe controller power-off button is shown in Figure 2-5. The LED light is out

Maintenance Operator Guide2-8 DocuTech 65/DocuPrint 65CAUTIONWhen the power on/standby switch is in stand-by and the AC power cord remains connected t

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-9Printer faultsOccasionally, a fault will occur at the printer that may prevent you from using th

DocuTech 65/DocuPrint 65 iIntroductionThe DocuTech 65/DocuPrint 65 Operator Guide is one of a number of publications which make up the Xerox Document

Maintenance Operator Guide2-10 DocuTech 65/DocuPrint 65Figure 2-6. Jam clearance areasArea 1 Sheets may be left in this area when jams occur.Area 2 Th

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-11Area 5 To access Areas 5, 5a, and 5b you need to open the Finisher area. The Finisher area is s

Maintenance Operator Guide2-12 DocuTech 65/DocuPrint 65Area 7 To access Area 7, you need to open the High Capacity Feeder (Tray 6) and Bypass Tray (Tr

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-13Replaceable units and suppliesThe printer is designed to allow the customer to change major com

Maintenance Operator Guide2-14 DocuTech 65/DocuPrint 65Replaceable itemsThe following components are replaceable:• The Xerographic Module• The Fuser M

Operator Guide MaintenanceDocuTech 65/DocuPrint 65 2-15Life expectancies and part numbers for CRUs and supplies are listed in Table 2-2.Table 2-2. Lif

Maintenance Operator Guide2-16 DocuTech 65/DocuPrint 65When placing orders, give the representative the following information:• Your Xerox customer nu

DocuTech 65/DocuPrint 65 3-13. Paper and other stockYour printer can process a variety of paper and other stock to accommodate your needs. This chapte

Paper and other stock Operator Guide3-2 DocuTech 65/DocuPrint 65Paper handling guidelinesPaper handling and/or image quality performance degradation m

Operator Guide Paper and other stockDocuTech 65/DocuPrint 65 3-3Tray capabilities: The trays are shown in Figure 3-2.Figure 3-2. Tray capabilitiesTray

Introduction Operator Guideii DocuTech 65/DocuPrint 65ContentsThis section lists the contents of this guide.•“Introduction” gives a basic overview of

Paper and other stock Operator Guide3-4 DocuTech 65/DocuPrint 65General stapling guidelinesTo ensure that stapling of thin sets is satisfactory, finis

Operator Guide Paper and other stockDocuTech 65/DocuPrint 65 3-5Performance tablesIn the printer performance tables, various symbols and characters ar

Paper and other stock Operator Guide3-6 DocuTech 65/DocuPrint 65NOTE: For all trays, the fusing quality and “fix level” for images on 65 lb. cover s

Operator Guide Paper and other stockDocuTech 65/DocuPrint 65 3-7The printer performance using standard 80 gsm paper in common Xerox Europe sizes is sh

Paper and other stock Operator Guide3-8 DocuTech 65/DocuPrint 65The printer performance for non-standard paper and other types of stock is shown in Ta

Operator Guide Paper and other stockDocuTech 65/DocuPrint 65 3-9The printer performance for new and recycled 8.5 x 11 inches (216 to 279 mm) or A4 pap

Paper and other stock Operator Guide3-10 DocuTech 65/DocuPrint 65Reinforced Mylar edge3 or 4 holesRinged binders • Load reinforced edge on the right i

Operator Guide Paper and other stockDocuTech 65/DocuPrint 65 3-11GBC stock (Sameceda)Plastic comb or strap binding via slotted holes or rectangles at

Paper and other stock Operator Guide3-12 DocuTech 65/DocuPrint 65Recommendations for handling, loading, and storing paperGive your paper the proper ha

DocuTech 65/DocuPrint 65 4-14. Problem solvingThis chapter will assist you in avoiding problems and solving those that may occur. It also provides inf

Operator Guide IntroductionDocuTech 65/DocuPrint 65 iiiRequirementsTelephone requirementsUSA FCC requirements:• The FCC has established rules that per

Problem solving Operator Guide4-2 DocuTech 65/DocuPrint 65Solving the problemsRecommendations for solving some common problems are listed in Table 4-1

Operator Guide Problem solvingDocuTech 65/DocuPrint 65 4-3Stock handlingThere are repeated stock jams or misfeeds in Tray 5.• Ensure that the correct

Problem solving Operator Guide4-4 DocuTech 65/DocuPrint 65Stock handlingThere are jams inside the printer.• Check the paper path for obstruction.• Mak

Operator Guide Problem solvingDocuTech 65/DocuPrint 65 4-5Calling the Welcome CenterIf you are experiencing difficulty with your printer, check the tr

Problem solving Operator Guide4-6 DocuTech 65/DocuPrint 65

Introduction Operator Guideiv DocuTech 65/DocuPrint 65Canadian industry requirementsNotice: The Canadian Industry Canada label identifies certified eq

Operator Guide IntroductionDocuTech 65/DocuPrint 65 vElectromagnetic comparabilityUnited StatesThis equipment has been tested and found to comply with